37 Years of the Digest ... founded August 21, 1981
Copyright © 2018 E. William Horne. All Rights Reserved.

The Telecom Digest for Sun, 26 Aug 2018
Volume 37 : Issue 202 : "text" format

Table of contents
Re: Four Conductor Telephone WireDavid
Re: Four Conductor Telephone WireDave Platt
Re: Four Conductor Telephone WireDoug McIntyre
Re: Four Conductor Telephone WireHAncock4
Re: Four Conductor Telephone WireJohn Levine
Please send posts to telecom-digest.org, with userid set to telecomdigestsubmissions, or via Usenet to comp.dcom.telecom
The Telecom Digest is made possible by generous supporters like John Lewandowski
---------------------------------------------------------------------- Message-ID: <5B819786.6020100@panix.com> Date: 25 Aug 2018 13:53:10 -0400 From: "David" <wb8foz@panix.com> Subject: Re: Four Conductor Telephone Wire On 8/23/18 2:39 PM, Fred Atkinson wrote: > > I hav been trying to locate a thousand foot roll of four conductor > telephone wire. > I refer to the grey wire the telephone installer would use to run > telephone extensions inside your home. What jacket were you seeking? It will be PVC or teflon; you can no longer get the 1930's cotton insulated stuff.... Further, I doubt you can find any 4-conductor unpaired (JKT) cable. (Maybe "theromostat wire.." but that will be a bigger gauge.) You want paired cable anyhow. > I would prefer to buy it locally rather than pay for shipping. Graybar > would have been ideal but they say they have nothing like that. I used to buy > it from them in the eighties and nineties. > > Other places tried to sell me CAT-5 or CAT-6. They had no clue what I > was even talking about. One place tried to sell me the satin extension cord > wire. They were clueless. CAT3/5 is far better. Home Depot sells it by the foot/box. It will avoid hum pickup when parallel with power distribution. <https://www.homedepot.com/p/Southwire-1-000-ft-Gray-24-4-Solid-CU-CAT5e-CMR-Riser-Data-Cable-56917949/202316502> Note: <https://www.homedepot.com/p/SPT-1000-ft-24-Gauge-CAT5E-Cable-Gray-4-Pair-CAT5-1000G/300605094> never says solid copper; it may be copper covered steel. Avoid it. +-------------------------------------------------------------------------+ + The Telecom Digest depends on generous supporters like John Levine + +-------------------------------------------------------------------------+ ------------------------------ Message-ID: <hu265f-sv9.ln1@coop.radagast.org> Date: 24 Aug 2018 12:29:53 -0700 From: "Dave Platt" <dplatt@coop.radagast.org> Subject: Re: Four Conductor Telephone Wire In article <02D05B1C-8682-4D71-A849-047A7226872D@mishmash.com>, Fred Atkinson <fatkinson.remove-this@and-this-too.mishmash.com> wrote: > I hav been trying to locate a thousand foot roll of four conductor >telephone wire. > > I refer to the grey wire the telephone installer would use to run >telephone extensions inside your home. As I recall, this is generally referred to as "station cable". Typically red/green/yellow/black, 22 gauge solid, not paired, jacketed together, not twisted particularly tightly, not impedance-controlled. > It doesn't need to be PVC as it won't be going inside walls, through >ceilings, or in an underfloor. It is just for running extensions to analog >[loop start] phones in a private home. I have a staple gun for running that >wire inside a private residence. I'm not sure why you're referring to PVC here, or excluding it. PVC (polyvinyl chloride) is a veyry comon wire insulator/shell, and I believe it's used for most of the ordinary grey-jacketed station cable I've ever seen. What you probably don't need, in this case, is "plenum-rated" cable. Plenum-rated cable has insulation which is relatively fire-resistant... in case of a fire it won't tend to act as an accelerant. Plenum-rated insulation _may_ be based on PVC (with fire retardants added) or a different insulation. https://www.cableorganizer.com/cat-cable/plenum-pvc.htm > I was given a Belden part number. That turned out to be PVC. It is >too expensive, not flexible enough, and not required for what I need. Carol Cable C4412.25.17 is probably one part number that would work. Parts Express carries it although they are currently out of stock. Zoro has it in stock (free ground shipping, drop shipped) for $67. > I would prefer to buy it locally rather than pay for shipping. Graybar >would have been ideal but they say they have nothing like that. I used to buy >it from them in the eighties and nineties. > > Other places tried to sell me CAT-5 or CAT-6. They had no clue what I >was even talking about. One place tried to sell me the satin extension cord >wire. They were clueless. My guess is that station cable has fallen out of popularity for new installations, because ordinary analog telephones are pretty much all it's good for. It may not work well for phone lines carrying DSL signals, or over-the-phone-line networking, and it's useless for Ethernet. Installers prefer to string Ethernet-qualified cable, as the price difference is minimal, it has many more potential applications, and it's very widely available. Consider this: the Carol Cable part I mentioned above, costs $76 for a 500-foot roll from Parts Express, or $67 from Zoro. If you go to Home Depot, you can buy a 1000-foot spool of Southwire 24/4-pair solid Cat5e gray-jacket cable for $97. That's twice as much wire (all that you would need) for less than twice Zoro's cost. And, it's better wire (the twisting of the pairs will make it somewhat more RF-interference-resistant). Yes, it's a bit thicker and heavier and less flexible than station cable (4 pairs, rather than 4 wires) but if you're going to be staple-gunning it into place that seems like a small inconvenience. +-------------------------------------------------------------------------+ + The Telecom Digest depends on generous supporters like John Levine + +-------------------------------------------------------------------------+ ------------------------------ Message-ID: <XY-dnfYBPcnF4BzGnZ2dnUU7-UHNnZ2d@giganews.com> Date: 25 Aug 2018 11:01:28 -0500 From: "Doug McIntyre" <merlyn@dork.geeks.org> Subject: Re: Four Conductor Telephone Wire "Fred Atkinson" <fatkinson.remove-this@and-this-too.mishmash.com> writes: > I hav been trying to locate a thousand foot roll of four conductor >telephone wire. > I refer to the grey wire the telephone installer would use to run >telephone extensions inside your home. > It doesn't need to be PVC as it won't be going inside walls, through >ceilings, or in an underfloor. .... First off you seem to be mixing up PVC vs. plenum jackets. Here you say it doesn't need to be PVC as it won't be going in walls, and then later you say that it was PVC and you didn't want it. PVC is by far the most common jacket material. When it burns, it could break down into its base material (ie. chrlorine). Then again, Romex is all in PVC jackets too. So, buying plenum rated cabling (ie. teflon) for residential seems kind of pointless, when you have 1000's of feet of Romex installed for your electrical. OOTH, commercial buildings in most jurisdictions require plenum rated cabling when it is installed in the plenum, because the air-handling is all pushed through the plenum. Unlike a residence, where the air handling is only pushed through ducts and air handling is not pushed through the walls. Most likely your 4-wire telephone wire was never produced in a plenum jacket. Only PVC. Next, just because it was widely used doesn't mean it was very good. They did have constant problems with the 4-wire telephone wire, but as you said, everybody just kept using it, as it was prevelent, damn the cross-talk problems that came with it. The industry got rid of it for a reason. What you are looking for is at least 4 generations removed from even old standards. Ie. after the 4-wire telephone wire came voice-grade or cat1 4-pair cabling, (which is also now not a thing now). Then cat3 4-pair (again, which also is now not a thing). But all new telephone installation wiring would be using cat5e 4-pair cabling. Some installers may use cat6 for phone wiring as well as their data wiring just to keep it all consistant, although there still is a cost difference between cat5e and cat6, although it is pretty small now, so they may just stock one kind of wire and not worry about it. (If you do enough wiring, you get into a groove with one vendor, get used to their twists, how thick the jacket is, etc. so you get used to that brand/model, and having to switch out throws you off a bit). If you really want to emulate as closely to what the old 4-wire telephone cable was, there is a modern equivilent. t-wire, or thermostat wire. You can buy it in plenum or pvc jackets (although see my comments above). You can buy something like a 20-4 section pretty much anywhere (ie. 20AWG, 4 conductor). It won't have the correct colors of conductors, but they'll be close. (ie. red-green-blue-white). If you go for 20-5, you'll pick up a yellow wire. Although as I've said, the industry abandonded what you are looking for for a reason, and twisted pair is definately the way to go for analog voice circuits. -- Doug McIntyre doug@themcintyres.us +-------------------------------------------------------------------------+ + The Telecom Digest would not be possible without the generous support + + of the Computer Science and Artificial Intelligence Laboratory at MIT + +-------------------------------------------------------------------------+ ------------------------------ Message-ID: <9630d0df-7eb1-40a9-b737-6b033178b12c@googlegroups.com> Date: 24 Aug 2018 14:25:40 -0700 From: HAncock4 <withheld@invalid.telecom-digest.org> Subject: Re: Four Conductor Telephone Wire On Friday, August 24, 2018 at 2:21:52 PM UTC-4, Fred Atkinson wrote: > Folks, > > I hav been trying to locate a thousand foot roll of four conductor > telephone wire. I think the proper name is "D Station Wire". But I can understand it being obsolete since apparently few people want landlines these days, so it isn't being installed. Amazon had a listing: https://www.amazon.com/Telephone-Station-Wire-Number-Conductors/dp/B0032V5AQS But since telephones normally need only two wires, wouldn't any 22 gauge (or thicker) paired wire do? +-------------------------------------------------------------------------+ + The Telecom Digest depends on generous supporters like John Lewandowski + +-------------------------------------------------------------------------+ ------------------------------ Message-ID: <plseq2$1ucv$1@gal.iecc.com> Date: 25 Aug 2018 20:39:31 -0000 From: "John Levine" <johnl@taugh.com> Subject: Re: Four Conductor Telephone Wire In article <02D05B1C-8682-4D71-A849-047A7226872D@mishmash.com>, Fred Atkinson <fatkinson.remove-this@and-this-too.mishmash.com> wrote: >Folks, > > I hav been trying to locate a thousand foot roll of four conductor >telephone wire. > > I refer to the grey wire the telephone installer would use to run >telephone extensions inside your home. If you search for "station cable" you can probably find it. I see a 1000' roll on Amazon for $256. Radio Shack has 100' rolls if it'd be adequate to buy ten of those. Just out of nosiness, what's it for? Nobody I know is wiring their houses for analog phones any more. It's either gig ethernet or fiber. -- Regards, John Levine, johnl@iecc.com, Primary Perpetrator of "The Internet for Dummies", Please consider the environment before reading this e-mail. https://jl.ly +-------------------------------------------------------------------------+ + The Telecom Digest depends on generous supporters like John Lewandowski + +-------------------------------------------------------------------------+ ------------------------------ ********************************************* End of telecom Digest Sun, 26 Aug 2018

Telecom Digest Archives